Comparison of different swab techniques for the quantitative analysis of mastitis relevant pathogens on liner surfaces
Schlagworte:
wet-dry swab technique, mechanical milk removal, mastitis prevention, sampling, bacterial densityAbstract
During machine milking, udder-pathogenic microorganisms can be transmitted. Unclean teats or milking of cows infected with mastitis pathogens can lead to contamination of the liner. To understand pathogen transmission through the liner, it is necessary to identify how many microorganisms adhere to the liner. Therefore, the microorganism density on the inner surface must be determined quantitatively. In this study, a multifactorial laboratory test was used to identify which is the best sampling technique and subsequent diagnostic procedure for quantitative analysis.
Liners were contaminated with several mastitis pathogens using a standardized procedure and four different sampling techniques were applied. Three of these techniques were wet-dry swabs (WDS); the first was performed with high contact pressure, the second with low contact pressure, and the third used high contact pressure with cosmetic swabs instead of swabs from laboratory supplies. These WDS techniques were compared with a dry swab (DS). Contamination was detectable in the used pathogens with all techniques. The use of a WDS is shown to have advantages over the DS, as the contact pressure applied to the swabs and the moisture of the swabs itself play an important role in recovery of pathogens. Thus, with the WDS with high contact pressure, a pathogen recovery of 2.503 log10cfu/cm² was achieved, while with the DS, only a value of 1.342 log10cfu/cm² was obtained. Our findings demonstrate that the different sampling techniques differ in their results and that there is a need for standardized sampling of the liner surface to compare the results of the microorganism density quantitively. The WDS technique in accordance with DIN 10113-1: 1997-07 for determining surface microbial counts in the food industry proves to be a more suitable method than the DS technique due to a higher recovery of microorganisms and uniform results of the determined microbial densities.
Literaturhinweise
Bradley A J: Bovine Mastitis: An envolving disease. Vet J. 2002; 164:2, 116-128
Seegers H, Fourichon C, Beaudeau F: Production effects related to mastitis and mastitis economics in dairy cattle herds. Vet Res. 2003; 34:5, 475-491
Halasa T, Huijps K, Østerås O, Hogeveen H: Economic effects of bovine mastitis and mastitis management: A review. Veterinary Q. 2007; 29:1, 18-31
German Veterinary Association. Leitlinien zur Bekämpfung der Mastitis des Rindes als Bestandsproblem. Verlag der DVG, Gießen. 2012
Barkema H W, Schukken Y H, Zadoks R N: Invited Review: The Role of Cow, Pathogen, and Treatment Regimen in the Therapeutic Success of Bovine Staphylococcus aureus Mastitis. J Dairy Sci. 2006; 89:6, 1877-1895
Ruegg P L: A 100-Year Review: Mastitis detection, management, and prevention. J Dairy Sci. 2017; 100:12, 10381-10397
Barkema H W, Schukken Y H, Lam T J G M, Beiboer M L, Benedictus G, Brand A: Management Practices Associated with the Incidence Rate of Clinical Mastitis. J Dairy Sci. 1999; 82:8, 1643-1654
Paduch J H, Krömker V: Colonization of the teat skin and the teat canal by mastitis pathogens in dairy cattle. Tierärztl Prax. 2011; 39:2, 71-76
Garcia A: Contagious vs. Environmental Mastitis. SDSU Extension Extra Archives. 2004; 126
Zadoks R N, Allore H G, Barkema H W, Sampimon O C, Gröhn Y T, Schukken Y H: Analysis of an Outbreak of Streptococcus uberis Mastitis. J Dairy Sci. 2001; 84:3, 590-599
Zadoks R N, Gillespie B E, Barkema H W, Sampimon O C, Oliver S P, Schukken Y H: Clinical, epidemiological and molecular characteristics of Streptococcus uberis infections in dairy herds. Epidemiol Infect. 2003; 130:2, 335-349
Sigrist SM: The role of bacterial contamination of milking utensils and disinfecting solutions in the pathogenesis of clinical mastitis in dairy cows. [Bakteriell kontaminierte Desinfektionsmittel und Gerätschaften beim Melkakt als mögliche Quelle für Mastitiden]. Diss. University of Zurich, Vetsuisse Faculty. 2010
Feldmann M, Zimmermann A, Hoedemaker M: Influence of milking technique, milking hygiene and environmental hygiene parameters on the microbial contamination of milking machines. Dtsch Tierarztl Wochenschr. 2006; 113:7, 274-281
Krömker V: Udder health and machine milking – pathogen transfer via direct mechanisms. Arch Lebensmittelhyg. 2014; 65:4, 95-97
Besier J, Lind O, Bruckmaier R M: Dynamics of teat-end vacuum during machine milking: types, causes and impacts on teat condition and udder health – a literature review. J Appl Anim Res. 2016; 44:1, 263-272
Krömker V: Short textbook dairy science and milk hygiene [Kurzes Lehrbuch Milchkunde und Milchhygiene]. Verlag Parey, Stuttgart. 2006; 1. Auflage.
Zimmermann A: Comparison of different techniques for the determination of bacteriological contamination of the milking equipment and possible interactions with milking procedures and udder-health. [Vergleich verschiedener Verfahren zur Beurteilung der mikrobiellen Kontamination der Melkzeuge bzw. der Melkanlage und mögliche Beziehungen zur Melktechnik und Eutergesundheit]. Diss. Stiftung Tierärztliche Hochschule Hannover. 2003
LeBlanc S J, Lissemore K D, Kelton D, Duffield T F, Leslie K E: Major advances in disease prevention in dairy cattle. J Dairy Sci. 2006; 89:4, 1267-1279
Böhm F, Krömker V: Current aspects of teat disinfection with special focus on premilking teat disinfection. Prakt Tierarzt. 2016; 97:2, 147-160
Blowey R, Edmondson P: Teat disinfection in dairy herds. In Pract. 1996; 18:6, 254-260
de Koning K, Ronningen O, Bjerring M, Ipema B: Testing of liners and measuring material properties. Bull Int Dairy Fed. 338/2004, 100 Years with liners and Pulsators in Machine Milking. 2004. 58-64
Gardner E R, Berridge N L: The deterioration of milking rubbers. 2. The effect of fat. J Dairy Res. 1952; 19:1, 31-38
Boast D, Hale M, Turner D, Hillerton E, Middleton N, Ohnstad I: Variation in the rubber chemistry and dynamic mechanical properties as liners age. Bulletin of the IDF no. 388/2004. 65-74
Pfannenschmidt F: Qualification of the Wet-dry-swab-technique DIN 10113; 1997-07 for the Determination of the Hygenic Status in Milking Machines. [Eignung des Nass-Trockentupfer Verfahrens (NTT) DIN 10113: 1997-07 zur Bestimmung des Hygienestatus in Melkanlagen]. Diss. Stiftung Tierärztliche Hochschule Hannover. 2003
Noorlander D O, Heckmann R: Scanning electron microscopy, a technique for Evaluating Milking Machine Inflations and Tubes. J Dairy Sci. 1980; 63:6, 991-1005
Svennesen L, Nielsen S, Mahmmod Y, Krömker V, Pederen K, Klaas I: Association between teat skin colonization and intramammary infection with Staphylococcus aureus and Streptococcus agalactiae in herds with automatic milking systems. J Dairy Sci. 2019; 102:1, 629-639
Nielsen C, Emanuelson U: Mastitis control in Swedish dairy herds. J Dairy Sci. 2013; 96:11, 6883-6893
Hovinen M, Pyörälä S: Invited review: Udder health of dairy cows in automatic milking. J Dairy Sci. 2011; 94:2, 547-562
Hay J R: The bacterial flora and disinfection of teat cups. Am J Vet Res. 1941; 2, 297-304
Moore G, Griffith C: Factors Influencing Recovery of Microorganisms from Surfaces by Use of Traditional Hygiene Swabbing. Dairy, Food environ sanit. 2002; 22:6, 410-421
Haverkamp H, Paduch J H, Klocke D, Hoedemarker M, Krömker V: Prevalence of teat end hyperkeratosis in lactating dairy cattle and their association with animal variables. Int J Env Agric Res. 2017; 3:9, 75-82
DIN 10113-1:1997-07: Determination of surface colony count on fitment and utensils in foodareas – Part 1: Quantitative swab method
Schmenger A, Krömker V: Characterization, Cure Rates and Associated Risks of Clinical Mastitis in Northern Germany. Vet Sci. 2020; 7:4, 170
Downloads
Veröffentlicht
Ausgabe
Rubrik
Lizenz
Copyright (c) 2023 Milchwissenschaft - Milk Science International
Dieses Werk steht unter der Lizenz Creative Commons Namensnennung 4.0 International.
